IELTS DATA Reading Test 17 The History of Papermaking

IELTS DATA Reading Test 17 The History of Papermaking


The History of Papermaking in the United Kingdom


The first reference to a paper mill in the United Kingdom was in a book printed by Wynken de Worde in about 1495. This mill belonged to a certain John Tate and was near Hertford. Other early mills included one at Dartford, owned by Sir John Speilman, who was granted special privileges for the collection of rags by Queen Elizabeth and one built in Buckingham shire before the end of the sixteenth century. During the first half of the seventeenth century, mills were established near Edinburgh, at Cannock Chase in Stafford shire, and several in Buckingham shire, Oxford shire and Surrey.

The Bank of England has been issuing bank notes since 1694, with simple watermarks in them since at least 1697. Henri de Portal was awarded the contract in December 1724 for producing the Bank of England watermarked bank-note paper at Bere Mill in Hampshire. Portals have retained this contract ever since but production is no longer at Bere Mill. There were two major developments at about the middle of the eighteenth century in the paper industry in the UK.

-----------------------------SPONSERS-----------------------------

The first was the introduction of the rag engine or Hollander, invented in Holland sometime before 1670, which replaced the stamping mills, which had previously been used, for the disintegration of the rags and beating of the pulp. The second was in the design and construction of the mould used for forming the sheet. Early moulds had straight wires sewn down on to the wooden foundation, this produced an irregular surface showing the haracteristic “laid” marks, and, when printed on, the ink did not give clear, sharp lines. Baskerville, a Birmingham printer, wanted a smoother paper.

James Whatman the Elder developed a woven wire fabric, thus leading to his production of the first woven paper in 1757. Increasing demands for more paper during the late eighteenth and early nineteenth centuries led to shortages of the rags needed to produce the paper. Part of the problem was that no satisfactory method of bleaching pulp had yet been devised, and so only white rags could be used to produce white paper. Chlorine bleaching was being used by the end of the eighteenth century, but excessive use produced papers that were of poor quality and deteriorated quickly.

By 1800 up to 24 million pounds of rags were being used annually, to produce 10,000 tons of paper in England and Wales, and 1000 tons in Scotland, the home market being supplemented by imports, mainly from the continent. Experiments in using other materials, such as sawdust, rye straw, cabbage stumps and spruce wood had been conducted in 1765 by Jacob Christian Schäffer. Similarly, Matthias Koops carried out many experiments on straw and other materials at the Neckinger Mill, Bermondsey around 1800, but it was not until the middle of the nineteenth century that pulp produced using straw or wood was utilised in the production of paper.

-----------------------------SPONSERS 1-----------------------------
-----------------------------SPONSERS-----------------------------

By 1800 there were 430 (564 in 1821) paper mills in England and Wales (mostly single vat mills), under 50 (74 in 1823) in Scotland and 60 in Ireland, but all the production was by hand and the output was low. The first attempt at a paper machine to mechanise the process was patented in 1799 by Frenchman Nicholas Louis Robert,but it was not a success.However, the drawings were brought to England by John Gamble in 1801 and passed on to the brother’s Henry and Sealy Fourdrinier, who financed the engineer Henry Donkin to build the machine.

The first successful machine was installed at Frogmore, Hertfordshire, in 1803. The paper was pressed onto an endless wire cloth, transferred to a continuous felt blanket and then pressed again. Finally it was cut off the reel into sheets and loft dried in the same way as hand made paper.In 1809 John Dickinson  patented a machine that that used a wire cloth covered cylinder revolving in a pulp suspension, the water being removed through the centre of the cylinder and the layer of pulp removed from the surface by a felt covered roller (later replaced by a continuous felt passing round a roller).

This machine was the forerunner of the present day cylinder mould or vat machine, used mainly for the production of boards.Both these machines produced paper as a wet sheet, which require drying after removal from the machine, but in 1821 T B Crompton patented a method of drying the paper continuously, using a woven fabric to hold the sheet against steam heated drying cylinders. After it had been pressed, the paper was cut into sheets by a cutter fixed at the end of the last cylinder.By the middle of the nineteenth century the pattern for the mechanised production of paper had been set.

Subsequent developments concentrated on increasing the size and production of the machines. Similarly, developments in alternative pulps to rags, mainly wood and esparto grass, enabled production increases.Conversely, despite the increase in paper production, there was a decrease, by 1884, in the number of paper mills in England and Wales to 250 and in Ireland to 14 (Scotland increased to 60), production being concentrated into fewer, larger units. Geographical changes also took place as many of the early mills were small and had been situated in rural areas.

The change was to larger mills in, or near, urban areas closer to suppliers of the raw materials (esparto mills were generally situated near a port as the raw material was brought in by ship) and the paper markets.

Questions The History of Papermaking in the United Kingdom


Questions 28 – 34

Do the following statements agree with the views of the writer of the reading
passage on The History of Papermaking in the U.K.?
In Boxes 28 – 34 write:
TRUE if the statement agrees with the writer
FALSE if the statement doesn’t agree with the writer
NOT GIVEN if it is impossible to say what the writer thinks about this

28 The printing of paper money in the UK has always been done by the same company.
29 Early paper making in Europe was at its peak in Holland in the 18th century.
30 18th Century developments in moulds led to the improvement of a flatter, more even paper.
31 Chlorine bleaching proved the answer to the need for more white paper in the 18th and 19th
centuries.
32 The first mechanised process that had any success still used elements of the hand made
paper-making process.
33 Modern paper making machines are still based on John Dickinson’s 1809 patent.
34 The development of bigger mills near larger towns was so that mill owners could take
advantage of potential larger workforce’s.

Questions 35 – 40

Match the events (35 – 40) with the dates (A – G) listed below.
Write the appropriate letters in boxes 35 – 40 on your answer sheet.

35 Invention of the rag engine.
36 A new method for drying paper patented.
37 First successful machine for making paper put into production.
38 Manufacture of the first woven paper.
39 Watermarks first used for paper money.
40 The first machine for making paper patented.

DATES

A 1803
B 1757
C 1821
D 1697
E 1799
F 1670
G 1694

ANSWERS of The History of Papermaking in the United Kingdom

28. TRUE
29. NOT GIVEN
30. TRUE
31. FALSE
32. TRUE
33. TRUE
34. FALSE
35. F
36. C
37. A

38. B

39. D

40. E

The History of Papermaking in the United Kingdom

Leave a Comment

Your email address will not be published. Required fields are marked *